酒店厨房的四套主要排烟设备中均设有济南酒店厨房排烟罩、排烟管道、排烟风机/风柜及前后端油烟净化器。酒店厨房排烟设备是排烟油烟，坚持厨房空气清新点设备。使用时间长，油烟等物品聚集在厨房的烟罩和烟管中，简单形成火灾隐患。
The four sets of main smoke exhaust equipment in the hotel kitchen are equipped with smoke hood, smoke exhaust pipe, smoke exhaust fan / cabinet and front and rear end fume purifier in Jinan hotel kitchen. The smoke exhaust equipment of the hotel kitchen is the smoke exhaust and oil smoke, and the kitchen air fresh point equipment shall be adhered to. Long use time, lampblack and other items gather in the smoke hood and pipe of the kitchen, which simply forms a fire hazard.
1. 厨房烟罩及前端油烟净化器的清洗方法
1. Cleaning method of kitchen hood and front end oil fume purifier
油烟进化器厨房排气罩和前油烟净化器一般设置为一体。
Lampblack evolutor kitchen exhaust hood and front lampblack purifier are generally set as a whole.
组件:防烟罩包括罩体和罩、防爆灯、前端净化器包括紫外线灯、川铁油网、水烟罩等。
Components: smoke proof cover includes cover body and cover, explosion-proof lamp, front-end purifier includes ultraviolet lamp, chuantie oil net, water smoke cover, etc.
清洁解决方案:防爆灯、紫外线灯可以用湿抹布擦干净,经常包含挡水板,水,油网,过滤网,如前端净化部分是一样的厨房排气罩面板,所有需求出现油垢铲干净,然后放入烧碱水泡沫,除了等待污泥完全泡沫破裂后,然后用高压水枪清洗(水)。根据经验，厨房80%的烟雾都不是的，主要原因是油烟净化器内置的过滤不洁插头。因此，清洗前端净化器的零件是非常重要的。
Clean solution: explosion-proof lamp and ultraviolet lamp can be cleaned with a wet cloth. It often contains water retaining boards, water, oil net and filter screen. For example, the front part is the same as the kitchen exhaust hood panel. All the requirements are greasy and shovel clean, and then put into the caustic soda water foam. After waiting for the sludge to completely burst, then use high pressure water gun to clean (water). According to experience, 80% of the smoke in the kitchen is not free. The main reason is that the filter plug inside the fume purifier is not clean. Therefore, it is very important to clean the parts of the front-end purifier.
2. 排气管的清洗方法
2. Cleaning method of exhaust pipe
排烟管道。部件:包括主管、消防阀、止回阀、调节阀、消声器管、软连接、弯头、三通等。
Smoke exhaust pipe. Components: including main pipe, fire valve, check valve, regulating valve, muffler pipe, soft connection, elbow, tee, etc.
清洗方法:清洗油烟管的要点是排气口与油烟罩的连接处，且油烟管与油烟罩平行，有必要彻底清洗这些地方。清洁管道弯头，如弯头、三通，必要时在弯头上方开孔。外部油烟管每隔一季清洗一次，但只有管肘一季清洗一次。
Cleaning method: the key point of cleaning the oil fume pipe is the connection between the exhaust port and the oil fume hood, and the oil fume pipe is parallel to the oil fume hood. It is necessary to thoroughly clean these places. Clean pipe elbows, such as elbows and tees, and make holes above the elbows if necessary. The external oil fume pipe shall be cleaned every other season, but only the elbow shall be cleaned once a season.
3.排风机/风柜的清洗方法
3. Cleaning method of exhaust fan / fan cabinet
风柜部件:风机包括电机等部件，风柜是将风机放入机柜，包括风机和机柜。
Fan cabinet component: fan includes motor and other components. Fan cabinet is to put fan into cabinet, including fan and cabinet.
清洗方法:清洗时先拆下电机或拆下电机风机叶片，再用铲式刀片清洗风机叶片上的油污及风机内部的残油，再用除油器清洗干净，再用清水清洗干净。
Cleaning method: first remove the motor or fan blade, then clean the oil stain on the fan blade and the residual oil inside the fan with shovel blade, then clean it with oil remover, and then clean it with clean water.
风机内外应清洗干净，防止腐蚀。
The inside and outside of the fan shall be cleaned to prevent corrosion.
4. 后端油烟净化器的清洗方法
4. Cleaning method of rear end oil fume purifier
排气油烟净化器。组件:电机和油烟处理系统(如滤料、静电处理设备、离心设备等)
Exhaust fume purifier. Components: motor and fume treatment system (such as filter material, electrostatic treatment equipment, centrifugal equipment, etc.)
清洗:根据油烟处理设备的类型进行相应的清洗操作，如更换滤料、清洗静电处理设备等。
Cleaning: carry out corresponding cleaning operation according to the type of fume treatment equipment, such as changing filter material, cleaning electrostatic treatment equipment, etc.
注意:清洁酒店厨房排烟设备时，需提前关闭电源。
Note: when cleaning the smoke exhaust equipment in the hotel kitchen, it is necessary to turn off the power in advance.
想排烟设备使用寿命长,还需要定期做一些日常维护:如清洁风扇,水风机,水风扇出现污渍,坚持管道小,确保运输罐清洁的水质,防止缺乏控制油柜等等。一旦发现异常现象，应及时找出原因并处理。这样才能减少隐患，不耽误厨房里忙碌的工作。
In order to prolong the service life of smoke exhaust equipment, it is necessary to do some routine maintenance on a regular basis, such as cleaning fan, water fan, water fan stains, adhere to small pipes, ensure clean water quality of transport tank, prevent lack of control oil tank, etc. Once abnormal phenomena are found, the causes shall be found out and handled in time. In this way, we can reduce the hidden danger and do not delay the busy work in the kitchen.
以上是
济南排烟罩公司小编为大家介绍的相关内容，想要了解更多内容，欢迎访问网站：http://www.jnqsg.com
The above is the relevant content introduced by Jinan smoke hood company. If you want to know more, please visit the website: http://www.jnqsg.com
上一篇：山东通风管道加工加固的过程及方法
下一篇：通风管道加工与创造低碳生活关系
