通风管道设备假设长期堆积杂质,这些杂质长期的滞留在机械设备内,在运转中会加快它的油凝结,温渡过高,构成气压阀、液压等部件的损坏,对正常运转构成很大的影响所以定期的对通风管道设备中止一次的清理是非常有必要的。比如：
It is assumed that impurities are accumulated in the ventilation pipe equipment for a long time. These impurities will stay in the mechanical equipment for a long time, which will accelerate its oil condensation during operation. The temperature transition is too high, which will cause damage to the pneumatic valve, hydraulic and other components, and have a great impact on the normal operation. Therefore, it is very necessary to stop a comprehensive cleaning of the ventilation pipe equipment on a regular basis. For example:
一些情况下需求在每日运转后中止清理,那就要每日都清理的,需求每个月清理一次的就要每个月对它清理一次,每次清理都要做好相应的清理记载,从而延长通风管道设备的运用寿命
In some cases, if it is required to stop cleaning after daily operation, it should be cleaned every day. If it is required to clean once a month, it should be cleaned once a month. Corresponding cleaning records should be made for each cleaning, so as to prolong the service life of ventilation pipe equipment
通风管道设备好三个月中止一次清理,这是由于,通风管道设备在长期运转当中,通常会产生一定的堆积物,而这些杂质会影响它液压系统的液压油的质量,假设这些杂质进入到油中并继续运转,又会构成更多的灰尘和杂质的进入,从而构成液压系统中油管的杂物增加,运转速度变慢,压力减小,以致无法运转等现象
The ventilation pipe equipment shall be completely cleaned every three months. This is because the ventilation pipe equipment usually produces certain deposits during long-term operation, and these impurities will affect the quality of the hydraulic oil of its hydraulic system. Assuming that these impurities enter the oil and continue to operate, they will form the entry of more dust and impurities, which will increase the sundries of the oil pipe in the hydraulic system, slow down the operation speed and reduce the pressure, So that it can not operate, etc
山东通风管道加工厂家提醒，还有就是一些通风管道设备假设长期堆积杂质,这些杂质长期的滞留在机械设备内,在运转中会加快它的油凝结,温渡过高,构成气压阀、液压等部件的损坏,对正常运转构成很大的影响。比如说：
Shandong ventilation pipe manufacturers remind that some ventilation pipe equipment is supposed to accumulate impurities for a long time. These impurities will stay in the mechanical equipment for a long time, which will accelerate its oil condensation during operation. The temperature transition is too high, which will cause damage to air pressure valve, hydraulic and other components, and have a great impact on normal operation. for instance:
当风道与除尘设备、加热设备等衔接前，应待设备装置终了后，按理论测绘的图纸中止预制和装置。通风管道装置时，进、出风日宜在风道预制时开出洞口，如需在装置终了的风道上现开风口，其接口处应紧密。
When the air duct is connected with the dust removal equipment, heating equipment, etc., the prefabrication and installation shall be suspended according to the theoretical mapping drawings after the equipment and installation are completed. When installing the ventilation duct, the air inlet and outlet shall be opened during the prefabrication of the air duct. If it is necessary to open an air outlet on the air duct at the end of the device, the interface shall be tight.
当运送含凝结水或含湿量较大的气体时，其水平管道宜设有坡度，并在低点处接排水管。装置时风道底部不宜呈现纵向接缝，对底部有接缝处应中止密封处置。对运送易燃、易爆气体的钢板风道，在风道衔接法兰处应装置跨接线，并与静电接地网衔接。
When transporting gas with condensate or high moisture content, its horizontal pipeline should be provided with a slope and connected with a drainage pipe at the low point. During installation, the bottom of the air duct should not have longitudinal joints, and the sealing treatment should be suspended at the joints at the bottom. For steel plate air duct transporting flammable and explosive gas, jumper wire shall be installed at the connecting flange of air duct and connected with electrostatic grounding grid.
当水平风道高度在4m以上时，装置人员应系带。脚手架或移动式支架上的跳板应固定好，跳板宽度应契合规范，在脚手架上的装置人员宜携东西袋，避免东西或电钻等物掉落伤人。双吊杆支架在风道就位后，应保证横担平直，吊杆不改动，双吊杆受力均匀。
When the height of the horizontal air duct is above 4m, the installation personnel shall wear safety belts. The springboard on the scaffold or mobile support shall be fixed properly, and the width of the springboard shall conform to the safety specifications. The installation personnel on the scaffold should carry bags to avoid falling things or electric drills and other objects from injuring people. After the double suspender support is in place in the air duct, ensure that the cross arm is straight, the suspender is not changed, and the double suspender is stressed evenly.
The above is the relevant content about the problem shared for you today. I hope it can help you. If you want to know more, you can contact us by phone or follow our website http://www.jnqsg.com 。
上一篇：油烟净化器的净化效果变差目前有三个原因
下一篇：想让油烟净化器达到满意净化效果有几个前提
