您好,欢迎访问山东燊赫通风设备有限公司网站!

服务热线

13210558111

控制排烟罩清洗周期的方案

来源:http://www.jnqsg.com/     发布时间:2017-06-03  

厨房排烟管道由于长时间的使用会积累很多污垢,这不仅会影响排烟效果,有时由于温度过高还会发生火灾。
Kitchen smoke exhaust pipe will accumulate a lot of dirt for a long time, which will not only affect the smoke exhaust effect, sometimes because of excessive temperature, there will be fire.
1、安装清洗人员先拆下管道的上截和下截,即空降法,此法主要用于清洗50公分见方以上的竖烟道。烟道上方固定高空绳,系上带,安装清洗人员从上下清洗竖烟道内的油污。此法危险性较大,技术性强,用度较高,清理效果好。因为竖烟道一般积油较少一年清洗一次即可。
1, the installation of cleaning personnel first remove the top section of the pipeline and the most inferior section, that is, airborne method, this method is mainly used for cleaning 50 cm square above vertical flue. Above the flue, secure the aerial safety rope, fasten the seat belt and install the cleaning personnel to clean the oil in the vertical flue from top to bottom. This method is more dangerous, more technical, higher cost and better cleaning effect. Because the vertical flue generally less oil, once a year can be cleaned.
2、此法劳动强度较大,即人工进入法,对于大于40公分见方的平行烟道可以人工钻进去进行清理。需要留意加强透风,配备低压(36伏)照明电源。
2, this method of labor intensity is larger, that is, artificial access law, for more than 40 cm square parallel flue, you can drill into the clean-up. Need to pay attention to strengthen ventilation, equipped with low-voltage (36 volts) lighting power supply.
3、人工无法进入时采用此法,即拆卸法,当烟道小于40公分见方时。安装清洗人员根据现场实际情况,每隔一定间隔拆卸一段烟道向两方延伸清理,此法效果好,难度较大,用度较高
3, the artificial can not enter the use of this method, that is, demolition method, when the flue is less than 40 cm square. Installation and cleaning personnel according to the actual situation at the scene, at intervals of a section of flue removal, cleaning to the two sides, the effect of this method is good, more difficult, higher cost
4、安装清洗人员采用专用无火花开孔工具将管道的一方或多方开孔,即开孔法,此法对于人工无法进入且拆卸较为难题的烟道采用此法。开孔大小、间隔、数目根据现场情况而定,油污清理完后将管道密封复原。
4. The installation and cleaning personnel use a special spark hole opening tool to open one or more sides of the pipe, that is, the opening method. This method is used for the flue which can not enter and disassemble more difficult. The size, spacing and number of the holes are determined according to the conditions of the field. After the oil is cleaned, the pipes are sealed and restored.
5、清洗周期短的烟道采用此法清理,即机器设备清洗法,对于油污较少。先将管道内喷洒清洗剂,使油污软化,再用30米长的电动软轴刷将油污洗擦干净。此法使用于30公分见方的竖烟道,人工无法进入且不便拆卸的隐蔽的小烟道。这种不易清洗而且轻易积油要缩短清洗周期。
5, cleaning cycle short flue using this method of cleaning, namely machine equipment cleaning method, for less oil pollution. The pipeline will be sprayed cleaning agent, so that oil softening, and then 30 meters long electric flexible brush to wash oil clean. This method is used in the vertical flue of 30 cm square, which can not be entered and can not be removed. This is not easy to clean and easy to accumulate oil, shorten the cleaning cycle.

上一篇:餐饮业的油烟污染的严重性
下一篇:不同类型的净化器其内部构造也不同